Expanding the Shelf-Life of Ready to use Shredded Icebergs by Using Oxidation - Reduction Potential controlled Release of Various Chlorine Concentrations in Washing Water

Mai Adnan  Abdullah; Heba Saed  Alawamleh; Moath S.  Al- Nasraween

doi:10.35516/jjas.v17i2.72

Authors

Mai Adnan Abdullah Al-Balqa Applied University, Jordan
Heba Saed Alawamleh Al-Balqa Applied University, Jordan
Moath S. Al- Nasraween Jordan Food and Drug Administration JFDA, Jordan

DOI:

https://doi.org/10.35516/jjas.v17i2.72

Keywords:

: Ready to Use fresh produce, Chlorination, lettuce (class Iceberg), Shelf-life, Minimal Processed Food

Abstract

Ready to use (RTU) shredded iceberg lettuce is a perishable product with a short shelf-life. Expanding the shelf life to seven days of this product as an economic need for the producers is the aim of this research. Fresh samples were harvested from the field and prepared according to the standard protocol of minimal processing fresh produce (receiving, removing dribs and pre-washing, washing, de-watering, packaging, and storing). Several concentrations of sodium hypochlorite were precisely optimized by oxidative/ reductive Potential (OPR) automated dozing pump under controlled neutral pH and cold temperature during washing regimen. Samples were vacuumed packed and kept tightly sealed at 4 °C for further analysis. Aerobic plate count and coliform as well as sensory evaluation were performed. Results showed that at a chlorine dose level less than 700 mV ORP, the shredded lettuce deteriorated due to elevated microbial load as well as from a sensory point of view. The level of 700 and 800 mV ORP extended shelf life for 7 days. Washing with chlorine levels higher than 800 mV showed alteration in sensory attributes although the microbial load was under control.

Results of this study show that the automated ORP chlorine dozing “in form of sodium hypochlorite” at 700 mV (50 ppm) and 800 mV (100 ppm) within controlled pH and temperature, followed by storing the vacuumed well-sealed packs at 4 °C, were the best measures taken to increase the shelf life of the shredded iceberg lettuce from 5 to 7 days. Furthermore, there was no significant difference between the uses of an ORP reading of 700 mV vs. 800 mV of chlorination. However, it is preferable to use the 700 mV ORP reading because it will release less chlorine in the washing water, hence, it will be healthier and more economical.

Downloads

Download data is not yet available.

Author Biographies

Mai Adnan Abdullah, Al-Balqa Applied University, Jordan

Department of Nutrition and Food Processing, Al-Huson University College, Al-Balqa Applied University, Jordan

Heba Saed Alawamleh, Al-Balqa Applied University, Jordan

Department of Basic Sciences, Al-Huson University College

Moath S. Al- Nasraween, Jordan Food and Drug Administration JFDA, Jordan

Head of the Imported Food Division- Jordan Food and Drug Administration JFDA, Jordan

References

Abadias, M., Alegreb, I., Oliveirab, M., Altisenta, R., and Viñasb, I. (2012). The growth potential of Escherichia coli O157: H7 on fresh-cut fruits (melon and pineapple) and vegetables (carrot and escarole) stored under different conditions. Food Control, 22: 37-44.

Abdullahi, I. O. and Abdulkareem, S. (2010). Bacteriological Quality of Some Ready to Eat Vegetables as Retailed and Consumed in Sabon-Gari, Zaria, Nigeria. Bayero Journal of Pure and Applied Sciences, 3(1): 173 – 175.

Allende, A., Selma, M. V., López-Gálvez, F., Villaescusa, R., and Gil, M. I. (2008). Role of commercial sanitizers and washing systems on epiphytic microorganisms and sensory quality of fresh-cut escarole and lettuce. Postharvest Biology and Technology, 49(1), 155–163. doi:10.1016/j.postharvbio.2007.12.010.

Bartz, J. A., Eayre, C. G., Mahovic, M. J., Concelmo, D. E., Brecht, J. K., and Sargent, S. A. (2001). Chlorine concentration and the inoculation of tomato fruit in packinghouse dump tanks. Plant Dis. 85:885-889.

Belitz, H.D., Grosch, W., Schieberle, P., (2004). Food Chemistry, third ed. Springer. Berlin.

Buchholz, U., Bernard, H., Werber, D., Böhmer, M.M., Remschmidt, C., Wilking, H., Deleré, Y., an der Heiden, M., Adlhoch, C., Dreesman, J., Ehlers, J., Ethelberg, S., Faber, M., Frank, C., Fricke, G., Greiner, M., Höhle, M., Ivarsson, S., Jark, U., Kirchner, M., Koch, J., Krause, G., Luber, P., Rosner, B., Stark, K., and Kühne, M. (2011). German outbreak of Escherichia coli O104: H4 associated with sprouts. N. Engl. J. Med., 365: 1763-1770.

Baur, S., Klaiber, R., Wie, H., Hammes, W.P., Reinhold, C., (2005). Effect of temperature and chlorination of pre-washing water on shelf-life and physiological properties of ready-to-use iceberg lettuce. Innov Food Sci Emerg. 6, 171-182.

Centre for Food Safety. (2014). Microbiological Guidelines for Food (For ready-to-eat food in general and specific food items). https://www.cfs.gov.hk/english/food_leg/files/food_leg_Microbiological_Guidelines_for_Food_e.pdf.

Cooley, M. B., Chao, D., and Mandrell, R. E. (2006). Escherichia coli O157:H7 survival and growth on lettuce is altered by the presence of epiphytic bacteria. J Food Prot. 69, 2329–

Couture, R., M.I. Cantwell, D. Ke , and M.E. Saltveit, Jr. (1993). Physiological attributes related to quality attributes and storage life of minimally processed lettuce. HortScience 28, 723-725.

FAO/WHO (Food and Agriculture Organization of the United Nations/World Health Organization). (2008). Microbiological hazards in fresh leafy vegetables and herbs: Meeting Report. Microbiological Risk Assessment Series No. 14. Rome. 151 pp.

Feng, P., Weagant, S. D., Grant, M. A. and Burkhardt, W. (2020). Enumeration of Escherichia coli and the Coliform Bacteria (Ch 4), in BAM Bacteriological Manual Ed 8, revision A/1998. https://www.fda.gov/food/laboratory-methods-food/bam-chapter-4-enumeration-escherichia-coli-and-coliform-bacteria.

Francis, G. A. (2013). Microbiological safety issues in prepared chilled produce. International Food Information Service (IFIS Publishing), FSTA: 1-28, www.ifis.org,

Ferguson, S., Roberts, C., Handy, E and Sharma, M. (2013) Lytic bacteriophages reduce Escherichia coli O157, Bacteriophage, 3:1, e24323, DOI: 10.4161/ bact.24323.

Fröder, H., Martins, C. G., de Souza, K. L. O., Landgraf, M., Franco, B. D. G. M., and Destro, M. T. (2007). Minimally Processed Vegetable Salads: Microbial Quality Evaluation. Journal of Food Protection, 70(5), 1277–1280. doi:10.4315/0362-028x-70.5.1277.

Fukumoto, L. R., Toivonen, P. M. A, and Delaquis, P. J. (2002). Effect of Wash Water Temperature and Chlorination on Phenolic Metabolism and Browning of Stored Iceberg Lettuce Photosynthetic and Vascular Tissues. J. Agric. Food Chem., 50 (16), 4503–4511.

Garcìa-Gimno, R. M. and Zurera-Cosano, G. (1997). Determination of Ready-to-Eat Vegetable Salad Shelf-Life. International Journal of Food Microbiology, 36, 31-38.

Gil, M. I., Selma, M. V., López-Gálvez, F., & Allende, A. (2009). Fresh-cut product sanitation and wash water disinfection: Problems and solutions. International Journal of Food Microbiology, 134(1-2), 37–45. doi:10.1016/j.ijfoodmicro.2009.05.021.

Heimdal, H., Kuhn, B.F., Poll, L., Larsen, L.M., (1995). Biochemical changes and sensory quality of shredded and MA-packaged iceberg lettuce. J. Food Sci. 60, 1-5.

Jeddi, M. Z., Yunesian, M., Gorji, M. E., Noori, N., Pourmand, M. R., and Khaniki, G. R. (2014). Microbial evaluation of fresh, minimally-processed vegetables and bagged sprouts from chain supermarkets. J Health Popul Nutr, 32(3):391-399.

Johnston, L. M., Jaykus, L., Moll, D., Anciso, J., Mora, B., Moe, C. L. (2006). A field study of the microbiological quality of fresh produce of domestic and Mexican origin, International Journal of Food Microbiology, 112(2), 83-95. https://doi.org/10.1016/j.ijfoodmicro.2006.05.002.

Kang, S., Min-Jeong K., AND Ung-Kyu C. (2007). Shelf-Life Extension of Fresh-Cut Iceberg Lettuce (Lactuca sativa L.) by Different Antimicrobial Films. J. Microbiol. Biotechnol., 17(8), 1284–1290

Kaneko, K., H. Hayashidani, K. Takahashi, Y. Shiraki, S. Limawongpranee, and M. Ogawa. (1999). Bacterial contamination in the environment of food factories processing ready-to-eat fresh vegetables. J. Food Prot. 62: 800-804.

Kim, J. G., Luo, Y., Saftner, R. A., and Gross, K. C. (2005). Delayed Modified Atmosphere Packaging of Fresh-cut Romaine Lettuce: Effect on Quality Maintenance and Shelf-life. J. Amer. Soc. Hort. Sci., 130(1): 116-123.

King, A. D., Magnuson, J. A., Torok, T., and Goodman, N. (1991). Microbial Flora and Storage Quality of Partially Processed Lettuce. J. Food Sci., 56: 459-461.

Lamikanra, O. (2002). Fresh-cut fruits and vegetables. Science, technology, and market. Boca Raton, FL: CRC Press.

López-Gálvez, F., Gil, M. I., Truchado, P., Selma, M. V., and Allende A. (2010). Cross-contamination of fresh-cut lettuce after a short-term exposure during pre-washing cannot be controlled after subsequent washing with chlorine dioxide or sodium hypochlorite. Food Microbiol. 27(2):199-204. doi: 10.1016/j.fm.2009.09.009.

Luo, Y., He, Q., and McEvoy, J. L. (2010). Effect of Storage Temperature and Duration on the Behavior of Escherichia coli O157:H7 on Packaged Fresh-Cut Salad Containing Romaine and Iceberg Lettuce. Journal of Food Science, 75 (7): M390-M397.

Ma, L., Zhang, M., Bhandari, B., and Gao, Z. (2017). Recent developments in novel shelf-life extension technologies of fresh-cut fruits and vegetables, Review Trends in Food Science & Technology, 64, 23–38.

Mahajan, P. V., Caleb, O. J., Singh, Z., Watkins, C. B., and Geyer, M. (2014). Postharvest treatments of fresh produce. Phil. Trans. R. Soc. A, 372: 20130309. http://dx.doi.org/10.1098/rsta.2013.0309.

Maturin, L. and Peeler, J. T (2001). Aerobic Plate Count (Ch. 3) in BAM Bacteriological Manual Ed 8, revision A/1998. https://www.fda.gov/food/laboratory-methods-food/bam-chapter-3-aerobic-plate-count.

Ono, T., Miyake, M., and Yamashita, K. (2005). Disinfection effect on vegetables by weak acid hypochlorous water to which a nonionic surfactant was added. J. Antibact. Antifungal. Agents, 33, 257-262.

Pan, X. and Nakano, H. (2014). Effects of Chlorine-Based Antimicrobial Treatments on the Microbiological Qualities of Selected Leafy Vegetables and Wash Water. Food Science and Technology Research, 20 (4), 765-774.

Parnell, T. L, Harris, L. J., and Suslow, T. V (2005). Reducing Salmonella on cantaloupes and honeydew melons using wash practices applicable to postharvest handling, foodservice, and consumer preparation. International Journal of Food Microbiology 99: 59 – 70.

Peryam, D. R. and Pilgrim, F. J. (1957). Hedonic Scale Method Of Measuring Food Preferences. Food Technology, 11: 9-14.

Rico, D., Martı´n- Diana, A.B., Barat, J.M. and Barry-Ryan, C. (2007). Extending and measuring the quality of fresh-cut fruit and vegetables: a review. Trends in Food Science & Technology, 18, 373-386.

Riva, M. Franzetti, L. and Galli, A. (2001). Microbiological Quality and Shelf-Life Modeling of Ready-to-Eat Cicorino Journal of Food Protection, 64. 2: 228–234

Saltveit, M.E., (2003). Fresh-cut vegetables, in Bartz, J.A., Brecht, J. K. (Eds.), Postharvest Physiology and Pathology of Vegetables, second ed., Revised and Expanded. Marcel Dekker Inc., New York, pp. 755-779.

SAS Institute. (2002). SAS User's Guide in Statistics, (9 th edition). Cary, NC., U.S.A.: SAS Institutes, Inc.

Suslow, T. V. (2001). Water Disinfection: A Practical Approach to Calculating Dose Values for Preharvest and Postharvest Applications. Publication 7256. The University of California. Agriculture and Natural Resources. Available from http://vric.ucdavis.edu.

Suslow T. V. (2000). Chlorination in the production of and postharvest handling of fresh fruits and vegetables; chap. 6: Fruit and vegetable processing. In: McLaren D. (ed). Use of chlorine-based sanitizers and disinfectants in the food manufacturing industry. Food Processing Center at the University of Nebraska, Lincoln. p. 2-15.